Kia Soul EV: Air Conditioning System / Electric A/C compressor Troubleshooting

Kia Soul EV (PS EV) 2015-2020 Service Manual / Heating,Ventilation, Air Conditioning / Air Conditioning System / Electric A/C compressor Troubleshooting

Troubleshooting

Fault code
Fail description
Remedy

61

Compressor CAN signal fault
Compressor operation state error receive
1. Check HV, LV  connector connection. 
2. Check LV connector pin condition. 
3. Check vehicle inverter fuse condition. 
4. A/C ON then check compressor operation. 
5. If not operating, replace compressor.
62
Low voltage
1. Check HV connector connection. 
2. Check vehicle inverter fuse condition. 
3. Check voltage level of high voltage battery. 
4. A/C ON then check compressor operation. 
5. If not operating, replace compressor.
63
High voltage
1. Identify vehicle model on compressor 
2. Check voltage level of high voltage battery. 
3. A/C ON then check compressor operation. 
4. If not operating, replace compressor.
64
Overheat protection
1. Check heating object in engine room. 
2. Check A/C system for defects. 
3. After 20 minutes, IG ON and A/C ON then check compressor operation. 
4. If not operating, replace compressor.
65
Overloaded
1. Check cooling fan operation. 
2. Check AAF(Active Air Flap) for short circuit 
3. After 20 minutes, IG ON and A/C ON then check compressor operation. 
4. If not operating, replace compressor.
66
Over current protection
68
Missed restart
71
Failure of Over torque stall
67
Abnormal (not receiving)
1. Check 12V battery fuse. 
2. Check LV connector connection. 
3. Check FATC CAN connection. 
4. If not operating, replace compressor.
69
Failure of thermistor open
1. Check thermistor condition and inspect.
70
Failure of thermistor short
72
Failure of short circuit current 
1. Replace compressor. 
2. Check vehicle inverter fuse (if necessary, replace).
73
Failure of driver voltage 
74
Failure of current measuring 
75
Failure max temperature gradient 
76
Failure Internal Error 

Electric A/C compressor Repair procedures
Removal     • Be sure to read and follow the “General Safety Information and Caution” before doing any work related with the high voltage system. Failure t ...

Condenser Components and Components Location
Component Location [Without Heat Pump] 1. Condenser ...

Other information:

Kia Soul EV (PS EV) 2015-2020 Service Manual: High Voltage Shut-off Procedures


High Voltage Shut-off Procedure     Be sure to read and follow the “General Safety Information and Caution” before doing any work related with the high voltage system. Failure to follow the safety instructions may result in serious electrical injuries. ...

Kia Soul EV (PS EV) 2015-2020 Service Manual: Brake Pedal Repair procedures


Removal 1. Turn ignition switch OFF and disconnect the negative (-) battery cable. 2. Remove the crash pad lower panel and reinforcing panel. (Refer to the Body group - crash pad) 3. Remove the lower duct (A). 4. Pull down steering column shaft after removing bolts and nuts. (Re ...

Copyright © www.ksoulev.com 2020-2025