Kia Soul EV: Tail Gate / Tail Gate Lift Repair procedures

Kia Soul EV (PS EV) 2015-2020 Service Manual / Body (Interior and Exterior) / Tail Gate / Tail Gate Lift Repair procedures

Replacement

•	Take care to not let the tail gate fall on you as the lifts are removed. Have a helper hold the tail gate open, or use a secure method to hold it open.

1.	Using a screwdriver (A), lift up slightly the socket clips (B) of both ends on the lifter (D), and then remove the lifter from the bracket (C).

Install in the reverse order of removal.

•	Make sure that the tail gate locks and opens properly and locks securely.

Tail Gate Back Panel Repair procedures

Replacement • Put on gloves to protect your hands. • When prying with a flat-tip screwdriver, wrap it with protec ...

Tail Gate Weatherstrip Repair procedures

Replacement 1. Remove the tail gate weatherstrip (A). • Do not apply sealant to the body. 2. Install in the reverse order of removal. & ...

Other information:

Kia Soul EV (PS EV) 2015-2020 Service Manual: Rear Wheel Speed Sensor Repair procedures

Removal 1. Remove the rear wheel & tire. Tightening torque: 88.3 ~ 107.9 N.m (9.0 ~ 11.0 kgf.m, 65.1 ~ 79.6 lb-ft) 2. Remove the rear wheel speed sensor. (Refer to Driveshaft and axle - "Rear Hub - Carrier") 3. Install in the reverse order of removal. ...

Kia Soul EV (PS EV) 2015-2020 Service Manual: Panorama Sunroof Motor Repair procedures

Inspection 1. Close the panorama sunroof glass and blind completely (Full close position). 2. Disconnect the negative (-) battery terminal. 3. Remove the roof trim assembly. (Refer to Body - "Roof Trim") 4. Remove the panorama sunroof glass motor (A) after loosening the screws and d ...