Kia Soul EV: Panorama Sunroof / Movable Glass Repair procedures

Kia Soul EV (PS EV) 2015-2020 Service Manual / Body (Interior and Exterior) / Panorama Sunroof / Movable Glass Repair procedures

Replacement
1.
Completely open the movable glass using the panorama sunroof switch.
2.
Remove both sides of the decoration cover (A) by pulling it in the direction of the arrow.

3.
Completely close the movable glass using the panorama sunroof switch.
4.
Adjust the height of the glass by slighty loosening the screws (A).
   
Be careful not to damage the screw.

5.
Carefully lift up the movable glass (A) and then remove it.

   
When installed the movable glass, put the tilt lever shoe (A) to the tilt lever.

6.
Install in the reverse order of removal.
   
After replacing the movable glass adjust the alignment if needed.
Repair procedures
Adjustment Inspect Glass Alignment 1. Inspect the alignment of the movable glass (C) that is between the front (A) and rear (B) glass and if needed adjust it. Alignment adjustment Standard v ...

Front Glass Repair procedures
Removal     • In order to remove the front glass, use the tools shown in the following figure: [Tooling Diagram] Square wire Insert-type wire grip [Tooling ...

Other information:

Kia Soul EV (PS EV) 2015-2020 Service Manual: Compressor Oil Repair procedures


Oil Specification 1. The HFC-134a system requires synthetic compressor oil (POE) whereas the R-12 system requires mineral compressor oil. The two oils must never be mixed. 2. Compressor oil (POE) varies according to compressor model. Be sure to use oil specified for the model of compress ...

Kia Soul EV (PS EV) 2015-2020 Service Manual: Brake Bleeding Prcoedure


AHB Brake System Bleeding procedure     • Do not reuse the drained fluid.. • Always use genuine DOT3/DOT4 brake fluid. Using a non-genuine DOT3/DOT4 brake fluid can cause corrosion and decrease the life of the system. • Make sure no di ...

Copyright © www.ksoulev.com 2020-2023